home register FAQ memberlist calendar

Go Back   Turbobricks Forums > Search Forums

Showing results 1 to 50 of 300
Search took 0.06 seconds.
Search: Posts Made By: hiperfauto
Forum: maintenance & nonperformance Yesterday, 11:31 PM
Replies: 8
Views: 90
Posted By hiperfauto
Late 140/164 use the same wiper system. The...

Late 140/164 use the same wiper system. The greenbook has a little better description and pictures in the electrical section.

http://www.240.se/litteratur/tp10868.pdf
Forum: maintenance & nonperformance Yesterday, 01:13 PM
Replies: 11
Views: 123
Posted By hiperfauto
The thumb screw adjusts the amount of air...

The thumb screw adjusts the amount of air bypassing the throttle plate. The assembly comes off with 2 screws.
...
Forum: performance & modifications 09-17-2018, 03:24 PM
Replies: 38
Views: 9,208
Posted By hiperfauto
Part #1216159 is a 240 rear axle with 3.15 gears....

Part #1216159 is a 240 rear axle with 3.15 gears. It's only listed in the '79-'84 parts catalog and it's definitely a 1031.

The tone ring is shown in the '79-'84 240 parts catalog with a note that...
Forum: performance & modifications 09-17-2018, 12:56 AM
Replies: 28
Views: 555
Posted By hiperfauto
Ferritic nitrocarburizing...

Ferritic nitrocarburizing (https://en.wikipedia.org/wiki/Ferritic_nitrocarburizing)
Forum: performance & modifications 09-16-2018, 10:37 PM
Replies: 28
Views: 555
Posted By hiperfauto
http://hiperformanceautoservice.com/images/R-Sport...

http://hiperformanceautoservice.com/images/R-Sport16ValveEngineBrochure.jpg
Forum: performance & modifications 09-16-2018, 01:43 PM
Replies: 55
Views: 1,318
Posted By hiperfauto
Here's the OE connector with wires. ...

Here's the OE connector with wires.

https://www.fcpeuro.com/products/volvo-side-marker-light-assembly-all-amber-1-1-1

Dave Barton sells the OE connector with his wires for less.
...
Forum: maintenance & nonperformance 09-16-2018, 01:44 AM
Replies: 7
Views: 246
Posted By hiperfauto
Those electronic catalogs are notoriously...

Those electronic catalogs are notoriously inaccurate. You need to go to the source.

http://www.gcp.se/katalog/modell/740-760/
Forum: performance & modifications 09-16-2018, 01:23 AM
Replies: 8
Views: 282
Posted By hiperfauto
If you have to have vented rotors on an 1800E you...

If you have to have vented rotors on an 1800E you could get Mr.Borrie's Amazon Wilwood caliper adapters (http://forums.turbobricks.com/showthread.php?t=282376) and a pair of caliper brackets from an...
Forum: maintenance & nonperformance 09-16-2018, 01:07 AM
Replies: 7
Views: 246
Posted By hiperfauto
I think the dealer is the only source for the...

I think the dealer is the only source for the IACV hoses. FCP will get them for you (from the dealer) as well. They're both still available. What part numbers were you looking for?
...
Forum: performance & modifications 09-14-2018, 04:31 PM
Replies: 5
Views: 361
Posted By hiperfauto
KL Racing has what you're looking for. This...

KL Racing has what you're looking for.

This pulley accepts a trigger wheel. The related parts for the sensor, brackets and trigger wheel are shown.
...
Forum: maintenance & nonperformance 09-14-2018, 03:40 PM
Replies: 2
Views: 211
Posted By hiperfauto
The part number didn't change. It's still...

The part number didn't change. It's still 1377669.

See this thread for more info.

http://forums.turbobricks.com/showthread.php?t=339610
Forum: maintenance & nonperformance 09-13-2018, 11:37 PM
Replies: 29
Views: 666
Posted By hiperfauto
Google Photos doesn't make it easy like some...

Google Photos doesn't make it easy like some other image hosting sites that provide a direct link to the image. I had to click on the image to open it full size, then right click to 'Copy image...
Forum: maintenance & nonperformance 09-13-2018, 09:00 PM
Replies: 29
Views: 666
Posted By hiperfauto
Here's your pics.

Here's your pics.
Forum: maintenance & nonperformance 09-12-2018, 10:06 PM
Replies: 13
Views: 472
Posted By hiperfauto
Try tapping on the main pump under the car with...

Try tapping on the main pump under the car with the fuel pump relay bypassed. Use a soft hammer (plastic or rubber ) or a screwdriver handle. It's common for the pumps to get stuck when they sit for...
Forum: maintenance & nonperformance 09-12-2018, 06:25 PM
Replies: 5
Views: 274
Posted By hiperfauto
There's a screw holding the cover on. ...

There's a screw holding the cover on.

http://hiperformanceautoservice.com/images/TestingLH_ComputerHarness.jpg
Forum: performance & modifications 09-12-2018, 05:26 PM
Replies: 38
Views: 751
Posted By hiperfauto
For which model/engine? NA 240/740 uses a 2"...

For which model/engine?

NA 240/740 uses a 2" cat.

https://www.summitracing.com/parts/mpe-332034

740/940 turbo uses a 2.5" cat.

https://www.summitracing.com/parts/mpe-332006
Forum: maintenance & nonperformance 09-11-2018, 02:24 PM
Replies: 16
Views: 527
Posted By hiperfauto
The lower shock bolt and spacer are still...

The lower shock bolt and spacer are still available. FYI, the bolt is M12-1.5 x 140mm.

https://www.tascaparts.com/oem-parts/volvo-hexagon-screw-970986
...
Forum: maintenance & nonperformance 09-11-2018, 12:44 AM
Replies: 3
Views: 300
Posted By hiperfauto
Did you check the timing belt?

Did you check the timing belt?
Forum: projects & restorations 09-09-2018, 07:00 PM
Replies: 566
Views: 104,849
Posted By hiperfauto
http://media.skandix.de/pimg/1032165.jpg

http://media.skandix.de/pimg/1032165.jpg
Forum: maintenance & nonperformance 09-08-2018, 02:30 PM
Replies: 10
Views: 435
Posted By hiperfauto
I think you've got the headlight switch wired...

I think you've got the headlight switch wired wrong. The taillights should have power in the first and second positions, the headlights should only have power in the second position. Power for the...
Forum: maintenance & nonperformance 09-05-2018, 11:44 PM
Replies: 4
Views: 365
Posted By hiperfauto
https://www.volvowholesalepartsdirect.com/p/428426...

https://www.volvowholesalepartsdirect.com/p/42842678/1277457.html

https://www.volvowholesalepartsdirect.com/images/parts/Volvo/parts/fullsize/GR-43736_37.png
Forum: maintenance & nonperformance 09-04-2018, 10:53 PM
Replies: 2
Views: 397
Posted By hiperfauto
124234 is iPd's part number for the LH2.2 FI temp...

124234 is iPd's part number for the LH2.2 FI temp sensor. It's not used on a K-Jet car.

Temperature related running issues can usually be traced to a malfunctioning CPR. Like dl242gt said, get a...
Forum: maintenance & nonperformance 09-02-2018, 06:10 PM
Replies: 6
Views: 376
Posted By hiperfauto
https://www.tascaparts.com/oem-parts/volvo-brake-p...

https://www.tascaparts.com/oem-parts/volvo-brake-pipe-1229857
https://www.tascaparts.com/oem-parts/volvo-brake-pipe-1229858
https://www.tascaparts.com/oem-parts/volvo-brake-pipe-1229859...
Forum: maintenance & nonperformance 08-31-2018, 10:24 PM
Replies: 5
Views: 334
Posted By hiperfauto
The greenbook says 0.9 MPa (130.5 psi).

The greenbook says 0.9 MPa (130.5 psi).
Forum: maintenance & nonperformance 08-31-2018, 04:09 PM
Replies: 25
Views: 1,534
Posted By hiperfauto
Yes, I can get you the seals and yes the sunroof...

Yes, I can get you the seals and yes the sunroof has to come out to change them although you might be able to do just the rear one without removing the sunroof.
Forum: maintenance & nonperformance 08-31-2018, 02:51 PM
Replies: 25
Views: 1,534
Posted By hiperfauto
The sunroof seals aren't really designed to keep...

The sunroof seals aren't really designed to keep out all of the water. There is a channel for water that enters through the sunroof seals that drains out of the front and rear roof pillars. If your...
Forum: maintenance & nonperformance 08-31-2018, 02:11 PM
Replies: 5
Views: 312
Posted By hiperfauto
You can also buy the connector with wires from...

You can also buy the connector with wires from FCP.

https://www.fcpeuro.com/products/volvo-side-marker-light-assembly-all-amber-1-1-1
Forum: maintenance & nonperformance 08-31-2018, 02:18 AM
Replies: 15
Views: 793
Posted By hiperfauto
Like this? ...

Like this?

http://hiperformanceautoservice.com/images/HPASSticker1.jpg
Forum: maintenance & nonperformance 08-31-2018, 01:46 AM
Replies: 15
Views: 793
Posted By hiperfauto
What do you think? ...

What do you think?

http://hiperformanceautoservice.com/images/HPASSticker.jpg
Forum: maintenance & nonperformance 08-30-2018, 02:32 PM
Replies: 20
Views: 693
Posted By hiperfauto
It'll run with the MAF disconnected, just not...

It'll run with the MAF disconnected, just not very well.
Forum: maintenance & nonperformance 08-30-2018, 01:29 PM
Replies: 20
Views: 693
Posted By hiperfauto
More commonly the cap on the booster check valve...

More commonly the cap on the booster check valve pops off and creates a wide open vacuum leak. Engine vacuum will keep it in place until it's shut off which explains why it ran fine until he parked...
Forum: maintenance & nonperformance 08-30-2018, 12:13 PM
Replies: 11
Views: 411
Posted By hiperfauto
FTFY and no, that's the headlight adjuster which...

FTFY and no, that's the headlight adjuster which is separate from the 3 headlight retainers.



Volvo's catalogs are notoriously inaccurate. For example, the '67-'72 140 catalog shows that only 2...
Forum: maintenance & nonperformance 08-29-2018, 10:08 PM
Replies: 11
Views: 411
Posted By hiperfauto
You need 3 of these clips for each headlight....

You need 3 of these clips for each headlight. Tighten the screw just enough to hold the headlight securely. Too tight and the clip will break.
...
Forum: projects & restorations 08-29-2018, 09:19 PM
Replies: 160
Views: 30,059
Posted By hiperfauto
That's an early 4½" 140/164 wheel. 1800E/ES never...

That's an early 4½" 140/164 wheel. 1800E/ES never got the oval hole wheels.

Gotta check those part numbers.

Oh yeah, you've got a 2 door rear seat bottom. That's why it looks funny.
Forum: maintenance & nonperformance 08-29-2018, 04:32 PM
Replies: 10
Views: 435
Posted By hiperfauto
The oil pressure switch wire goes under the crank...

The oil pressure switch wire goes under the crank and up to the 8 pole grey connector on the firewall.
Forum: maintenance & nonperformance 08-29-2018, 03:30 PM
Replies: 17
Views: 455
Posted By hiperfauto
I wouldn't mess with it unless it's leaking and...

I wouldn't mess with it unless it's leaking and you're going to pull it off to reseal it. The switch assembly will come apart when removed and it's no fun trying to piece it back together in situ.
Forum: maintenance & nonperformance 08-29-2018, 03:25 PM
Replies: 10
Views: 435
Posted By hiperfauto
It's an odd size so nothing at the auto parts...

It's an odd size so nothing at the auto parts store fits very well. Volvo sells repair wires for this purpose.

https://www.ipdusa.com/uploads/images_products_slideshow/fullsize_3051.jpg

I found...
Forum: maintenance & nonperformance 08-29-2018, 02:05 PM
Replies: 17
Views: 455
Posted By hiperfauto
No, the proportioning valves are under the car by...

No, the proportioning valves are under the car by the fuel pump.

http://hiperformanceautoservice.com/images/ProportioningValves.jpg

The warning valve is also a distribution manifold. Actually,...
Forum: maintenance & nonperformance 08-29-2018, 12:37 PM
Replies: 17
Views: 455
Posted By hiperfauto
If there's brake fluid coming out of the switch,...

If there's brake fluid coming out of the switch, the octopus is bad. You can take it apart and replace the leaking o-rings or replace it with a new one. You can also use the octopus without a warning...
Forum: maintenance & nonperformance 08-29-2018, 01:54 AM
Replies: 17
Views: 455
Posted By hiperfauto
What year is your 240? You either have a switch...

What year is your 240? You either have a switch on the octopus (brake warning valve) or on the brake fluid reservoir that will turn on the light.

The warning valve on the octopus indicates a...
Forum: maintenance & nonperformance 08-28-2018, 09:58 PM
Replies: 8
Views: 316
Posted By hiperfauto
I don't believe so. There's no rubber molding...

I don't believe so. There's no rubber molding listed nor are there any clips for the trim which is odd. What holds it on?




Ah! That explains it.
Forum: performance & modifications 08-28-2018, 07:27 PM
Replies: 59
Views: 1,934
Posted By hiperfauto
The gasket is part #1378490. ...

The gasket is part #1378490.

http://www.skandix.de/en/spare-parts/engine/fuel-mixture-formation/injection-system/mass-airflow-sensor-airflow-meter/gasket-flow-divider/1014798/
Forum: maintenance & nonperformance 08-28-2018, 07:18 PM
Replies: 4
Views: 465
Posted By hiperfauto
The greenbook says 2.9 lbs. of R12 which is 46.4...

The greenbook says 2.9 lbs. of R12 which is 46.4 oz. and 300cm³ (.64 US pint or 10.24 oz.) of oil although it says the compressor should come filled with the proper amount and to make a dipstick to...
Forum: maintenance & nonperformance 08-28-2018, 05:09 PM
Replies: 8
Views: 316
Posted By hiperfauto
Yeah, that's the correct part number for the...

Yeah, that's the correct part number for the molding. Earlier cars used the same stainless steel trim that 140/164's used.

See this thread for more info.
...
Forum: maintenance & nonperformance 08-27-2018, 02:16 PM
Replies: 15
Views: 793
Posted By hiperfauto
How's this? ...

How's this?

http://hiperformanceautoservice.com/images/hpas1.png
Forum: maintenance & nonperformance 08-27-2018, 01:59 AM
Replies: 10
Views: 561
Posted By hiperfauto
I heard the guys over at Hi Performance Auto do a...

I heard the guys over at Hi Performance Auto do a decent job of rebuilding those Skinner Union carbs. They send out the throttle bodies to have the throttle shafts replaced and then rebuild them with...
Forum: performance & modifications 08-26-2018, 09:47 PM
Replies: 15
Views: 604
Posted By hiperfauto
Put it on dry but lube the part that touches the...

Put it on dry but lube the part that touches the bearing retainer with a little bearing grease. Make sue it sits flat so it will make contact all the way around.
Forum: performance & modifications 08-26-2018, 06:46 PM
Replies: 15
Views: 604
Posted By hiperfauto
Clean and inspect the bearings and races. Replace...

Clean and inspect the bearings and races. Replace as necessary.

Definitely get new seals, they're cheap.

https://www.ipdusa.com/products/7255/101454-front-wheel-seal-200

This is how you...
Forum: maintenance & nonperformance 08-26-2018, 12:55 PM
Replies: 13
Views: 451
Posted By hiperfauto
Those should work although you could probably...

Those should work although you could probably have something similar made locally.
Forum: maintenance & nonperformance 08-26-2018, 01:05 AM
Replies: 13
Views: 451
Posted By hiperfauto
Not really. If you look at that catalog it lists...

Not really. If you look at that catalog it lists the 215mm pressure plate and throw out bearing but no disc.
Showing results 1 to 50 of 300

 
Forum Jump

All times are GMT -4. The time now is 03:18 AM.

Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2018, vBulletin Solutions Inc.